JASCO CHEMICAL -- PREP & PRIMER, 718 -- 8010-00N060431 
=====================  Product Identification  =====================

Product ID:PREP & PRIMER, 718
MSDS Date:10/24/1989
FSC:8010
NIIN:00N060431
=== Responsible Party ===
Company Name:JASCO CHEMICAL
Address:1710 VILLA ST
Box:J
City:MOUNTAIN VIEW
State:CA
ZIP:94042
Country:US
Info Phone Num:415-968-6005
Emergency Phone Num:800-424-9300(CHEMTREC)
Preparer's Name:J.C.Z.
CAGE:FO802
=== Contractor Identification ===
Company Name:JASCO CHEMICAL
Address:1710 VILLA STREET
Box:J
City:MOUNTAIN VIEW
State:CA
ZIP:94042
Phone:(415) 968-6005
CAGE:FO802
Company Name:JASCO CHEMICALS
Address:1710 VILLA ST
Box:J
City:MOUNTAIN VIEW
State:CA
ZIP:94042
Country:US
Phone:415-968-6005, 800-424-9300
CAGE:9B440

=============  Composition/Information on Ingredients  =============

Ingred Name:PHOSPHORIC ACID; (PHOSPHORIC ACID 75%; ORTHOPHOSPHORIC
    ACID)  (SARA 313) (CERCLA). VP:15 @ 104F.
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 44%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3;3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:ETHYLENE OXIDE; (ICEPAL CO-630 SPECIAL SURFACTANT)	(SARA
    302/313) (CERCLA)
CAS:75-21-8
RTECS #:KX2450000
Fraction by Wt: 0.2%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

Ingred Name:DICHROMIC ACID, DIPOTASSIUM SALT; (POTASSIUM DICHROMATE
    (BICHROMATE))  (SARA 313) (CERCLA)
CAS:7778-50-9
RTECS #:HX7680000
Fraction by Wt: 0.2%
OSHA PEL:0.1 MG/M3 (CRO3), C
ACGIH TLV:0.5 MG/M3 (CR)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL BUTYL ETHER). VP:0.9 @
    77F.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S

Ingred Name:CHROMIUM; (CHROMIUM COMPOUNDS)  (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: TRACE
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

Ingred Name:VOLATILE ORGANIC COMPOUNDS: COATING - 0.58 LBS/GAL (70
    G/L).
RTECS #:9999999VO

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:YES
Health Hazards Acute and Chronic:THIS PRODUCT IS CORROSIVE & WILL CAUSE
    DESTRUCTION OF SKIN TISSUE &/OR MUCOUS MEMBRANES. INHAL:IRRITATION
    TO MUCOUS MEMBRANES, BURNING SENSATION TO NOSE & THROAT. SKIN & EYE
    CONTACT:THIS PRODUCT IS CO RROSIVE & MAY CAUSE BURNING. SKIN
    ABSORPTION:DESTRUCTION OF TISSUE. PRIMARY IRRITANT DERMATITIS.
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ETHYLENE OXIDE:IARC MONOGRAPHS ON EVAL
    OF CARCIN RISK OF CHEMS TO MAN, VOL 60, PG 73, 1994:GRP 1. NTP 7TH
    ANNUAL(SUPDAT)
Effects of Overexposure:HLTH HAZ:INGEST:DESTRUCTION TO DIGEST TRACT,
    CHOKING, COUGH, VOMIT. ANIMAL STUDIES CLEARLY DEMONSTRATED
    DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC TISSUES, BLOOD,
    KIDNEYS & LIVER, ASSOC W/ADM IN OF ETHYLENE GLYCOL MONOBUTYL EHTER
    (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO.90-118) .
Medical Cond Aggravated by Exposure:SKIN CONDITIONS MAY BE AGGRAVATED.
    MATERIAL IS CORROSIVE & WILL CAUSE BURNS.

=======================  First Aid Measures  =======================

First Aid:SKIN:FLUSH W/WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL
    ATTENTION IF IRRITATION PERSISTS. EYES:FLUSH W/WATER FOR AT LEAST
    15 MINUTES. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
    INHAL:REMOVE VICTI M TO FRESH AIR. RESTORE BREATHING IF NECESSARY.
    SEEK MEDICAL ATTENTION IF BREATHING REMAINS DIFFICULT. INGEST:DO
    NOT INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point:NONE
Lower Limits:1.1%
Upper Limits:10.6%
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT . USE WATER SPRAY TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:EXTINGUISH ALL IGNITION SOURCES. HYDROGEN
    GAS MAY BE LIBERATED BY CONTACT W/SOME METALS.

==================  Accidental Release Measures  ==================

Spill Release Procedures:WEAR PROTECTIVE CLOTHING. CONTAIN & NEUTRALIZE
    W/BICARBONATE OR SODA ASH. KEEP MATERIAL OUT OF SEWERS & WATER
    SOURCES.
Neutralizing Agent:BICARBONATE OR SODA ASH.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP IN A VENTILATED AREA. STORE IN AN
    UPRIGHT POSITION. STORE AT TEMPERATURES FROM 70-80F.
Other Precautions:EMPTY CONTAINERS SHOULD BE HANDLED AS IF THEY WERE
    FULL; OBSERVE ALL HAZARD WARNINGS. MATERIAL IS CORROSIVE.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IF TLV IS
    EXCEEDED.
Ventilation:LOCAL EXHAUST IS ACCEPTABLE, BUT MECHANICAL EXHAUST IS
    RECOMMENDED.
Protective Gloves:ACID RESISTANT SUCH AS LATEX RUBBER.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:ACID RESISTANT SUIT, RUBBER APRON, RUBBER
    BOOTS, SAFETY SHOWER/EYEWASH.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE AROUND PRODUCT.
Supplemental Safety and Health
EXPLAN OF CARCIN:RPT ON CARCINS, 1994:ANTIC TO BE CARCIN. CFR VOL 29,
    PG 1910.1047, 1987, OSHA CANCER HAZ. ANIMAL:BLOOD, LIVER. POTASSIUM
    DICHROMATE:IARC MONOGRAPHS ON EVAL OF CARCIN RISK OF CHEMS TO  MAN,
    VOL 49, PG 49, 1990:GRP 1. NTP 7THANNUAL RPT ON CARCINS:KNOWN TO BE
    CARCIN. EYE PROT:& FULL LENGTH FCSHLD .

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:203F,95C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.2 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:GREEN-BLUE LIQUID; ACIDIC ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
ALKALIS, OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:MAY LIBERATE HYDROGEN GAS OR
    PHOSPHOROUS OXIDES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.