XEROX CORP -- 5760/5765/5790/DUROCOLOR 40 BLACK TONER, 6R843  -- 6850-00N078005
<pre>=====================  Product Identification  =====================

Product ID:5760/5765/5790/DUROCOLOR 40 BLACK TONER, 6R843
MSDS Date:04/25/1996
FSC:6850
NIIN:00N078005
=== Responsible Party ===
Company Name:XEROX CORP
Address:100 CLINTON AVE S
City:ROCHESTER
State:NY
ZIP:14644
Country:US
Info Phone Num:800-828-6571
Emergency Phone Num:714-422-2177;714-422-1230
CAGE:0E6G9
=== Contractor Identification ===
Company Name:XEROX CORP
Address:300 MAIN ST NO 27C
City:EAST ROCHESTER
State:NY
ZIP:14645
Country:US
Phone:800-828-6571; 800-351-2024
CAGE:0E6G9
Company Name:XEROX CORPORATION
Address:100 CLINTON AVE SOUTH
Box:City:ROCHESTER
State:NY
ZIP:14644-1877
Country:US
Phone:800-828-6571/716-422-2177
CAGE:26921

=============  Composition/Information on Ingredients  =============

Ingred Name:POLYESTER
CAS:128781-91-9
Fraction by Wt: >90%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 2-5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3

Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 G/KG
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:YES	 OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MINIMAL RESP TRACT IRRIT MAY
    OCCUR AS W/EXPOS TO LG AMTS OF ANY NON-TOXIC DUST. TOX:CHRONIC
    TONER INHAL STUDY, DEMONSTRATED NO LUNG CHANGE IN RATS IN LOWEST
    (1MG/M3) EXPOS LEVEL (I.E. LEVEL MOST  RELEVANT TO POTNTL HUMAN
    EXPOS). VERY SLIGHT DEGREE OF FIBROSIS WAS NOTED IN 1/4 OF ANIMALS
    @ MIDDLE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK:IARC MONO ON EVAL OF CARCIN
    RISK OF CHEMS TO MAN, VOL 65, PG 24-27, 1995:GROUP 2B.
Effects of Overexposure:HLTH HAZ:(4MG/M3) EXPOS LEVEL, WHILE SLIGHT
    DEGREE OF FIBROSIS WAS NOTED IN ALL ANIMALS @ HIGHEST (16MG/M3)
    EXPOS LEVEL. FINDINGS ARE ATTRIBUTED TO "LUNG OVERLOADING", GENERIC
    RESPONSE TO EXCESS AMTS  OF ANY DUST RETAINED IN LUNGS FOR PRLNGD
    PERIOD. THIS STUDY WAS CONDUCTED USING SPEC TEST TONER TO COMPLY
    W/EPA (SUPDAT)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
    PRODUCT LITERATURE.

=======================  First Aid Measures  =======================

First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:WASH WITH
    SOAP AND WATER. INHALTION:REMOVE FROM EXPOSURE. INGESTION:DILUTE
    STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.

=====================  Fire Fighting Measures  =====================

Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
    ORGANIC MATLS IN POWDER FORM, WHEN DISPERSED IN AIR, IT CAN FORM
    EXPLOSIVE MIXTURES.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SWEEP UP/VACUUM SPILLED TONER & CAREFULLY
    TRANSFER INTO SEALABLE WASTE CNTNR. SWEEP SLOWLY TO MINIMIZE
    GENERATION OF DUST DURING CLEAN-UP. IF VACUUM IS USED, MOTOR MUST
    BE RATED AS DUST TIGHT. CONDUCT IVE HOSE BONDED TO MACHINE SHOULD
    BE USED (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:NONE.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED. NIOSH
    APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:TESTING PROTOCOL. TEST TONER WAS 10 TIMES MORE
    RESPIRABLE THAN COMMERCIALLY AVAIL XEROX TONER, & WOULD NOT BE
    FUNCTIONALLY SUITABLE FOR XEROX EQUIPMENT. SPILL PROC:TO REDUCE
    STATIC BUI LDUP. RESIDUE CAN BE REMOVED W/SOAP & COLD WATER.
    GARMENTS MAY BE WASHED/DRY CLEANED, AFTER REMOVAL OF LOOSE TONER.

==================  Physical/Chemical Properties  ==================

Solubility in Water:NOT KNOWN
Appearance and Odor:BLACK POWDER/FAINT ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
    AVOID BREATHING SMOKE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:WHEN DISPOSED, MATL IS NOT HAZ WASTE ACCORDING
    TO FED REGS 40 CFR 261. HOWEVER, STATE & LOCAL REQUIREMENTS MAY BE
    MORE RESTRICTIVE. THEREFORE, CONSULTATION W/APPROP FEDERAL, STATE &
    LOCAL WASTE DISP A UTH IS ADVISED. INCIN ONLY IN CLSD CNTNR.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.